Ambitious but Flawed Aircraft Concepts
So when an airplane disintegrates in midflight or can only be operated successfully by expert pilots with hours of training, that plane joins hundreds of others that were great in theory, but never made it to mass production. Here we present you with ten of the ambitious and flawed aircraft concepts, and why only a few of them ever got made.
Follow InnovationNewsDaily on twitter @News_Innovation, or on Facebook.
HK-1 Hercules (The Spruce Goose)
The 400,000-pound wooden airplane had a 320-foot wingspan (that’s just 40 feet less than a football field) and was proposed as a way to build a plane that could carry troops and cargo without using precious wartime materials. The plane had a single large hull, produced thrust with eight engines and by the time it was completed in 1947, had cost the U.S. government $22 million and Hughes $18 million.
Hughes planned for the plane to carry 750 fully equipped troops or one M4 Sherman tank. The HK-1 was the largest airplane ever built up to that point, in fact, it was three times larger than any plane that came before it. Despite all the money and time that went into its creation, the plane only flew once; it traveled a distance of one mile, at a height of about 33 feet.
The Aerocycle carried a single pilot and its engine on a circular platform, all of which was located just above two 15-foot long rotating propellers. The craft’s pilot would stand toward the rear of the platform, secured by a tether attached to the steering column.
Single person flying platforms were going to be used for reconnaissance missions. The belief was that they were easy to pilot so little experience was needed to operate one. They learned otherwise during the testing phase when two pilots crashed because the Aerocycle was ‘too hard to steer without experience.
The plane was finally tested in 1957, but was never developed further due to a lack of operational requirement. The military simply had no use for it on the battlefield anymore.
The pod was positioned below the fuselage and made getting cargo on and off the plane much quicker – the pod could be removed, a new one placed in and the aircraft would be ready for take off again. The Packplane’s upper component had a flat bottom and could be flown without the cargo hold being attached.
The company only built one XC-120, but the idea was never pursued further as it didn′t really improve that much on airplanes with traditional cargo carrying compartments.
Nicknamed the ‘Flying Egg,’ the Goblin was meant to act as a defender – a parasite fighter – which would be dropped from the bomb bay of the mother ship to deal with enemy fighters while it’s carrier, the Peacemaker B-36, went on its way. Because it needed to fit in the bay of the B-36, there were a lot of size constraints. The Goblin could only be sixteen feet long, and only five feet wide when stowed. Its wings were designed to fold up alongside each side of the fuselage to fit into the B-36.
There were multiple reasons that the Goblin never made it past the testing phases. The little plane was no match for conventional enemy fighters: it was too slow and too lightly armed. In addition, the increasing range of jet escort fighters, thanks to the advent of in-flight refueling, allowed them to accompany bombers on their full missions.
Convair XFY Pogo
It was an experiment in vertical takeoff and landing. The plane was known as a tailsitter because it launched and landed on its tail. Its developers believed that this would make it possible to operate them from small warships.
Issues with the Pogo’s design prevented it from leaving the testing phase. Because it was so lightweight and had no spoilers, it lacked the ability to slow down and stop efficiently after moving at high speeds.
Landing also turned out to be a problem. The pilot had to look back behind himself during a landing to properly stabilize the craft. So like the Aerocycle, the Pogo could only be flown by the most experienced pilots.
A-12 Avenger II
The A-12 was designed to be an all-weather, carrier-based stealth bomber based from air carriers. It was shaped like an isocles triangle, with a cockpit at the vertex. Its internal weapons bay would carry smart bombs and other air-to-ground ordnance.
In the end the ‘flying dorito’ as it was nicknamed proved to be too expensive for development. By one estimate the A-12 had become so expensive that it would have consumed up 70 percent of the Navy's aircraft budget within three years.
F2Y Sea Dart
The F2Y was the winner of the Navy’s 1948 competition for a supersonic interceptor aircraft. The Navy was worried about operating supersonic aircraft from the decks of aircraft carriers so the Sea Dart seemed like the perfect solution as it rode on twin hydro-skis for takeoff.
Despite its horrific final flight, the Sea Dart does hold one record as the only seaplane to ever go faster than the speed of sound.
Developed in 1957, the X-20 Dyna-Soar (dynamic soarer) was a U.S. Air Force program to develop a space plane that could be used for military missions, such as reconnaissance, bombing, space rescue, satellite maintenance and sabotage of enemy satellites.
While other space planes at that time were based on space capsules, which means they relied on the atmosphere’s drag to slow them down. The Dyna-Soar was much more similar to our space shuttles, which glide to earth under the guidance of a pilot.
The Dyna-Soar never made it beyond a test plane because the Air Force has no clear goal for the aircraft, and its developers were uncertain that the boosters would have the power to effectively launch the plane into space.